For scheduling, go toThe 24k Gold Ticketing site
Keep
the Drain Pan Clean
Door
Gasket
Fridge isn't
running, no sound can be
heard and the light is out
Fridge
isn't running, the light is on and you hear occasional
clicking
Fridge constantly cycles
on and off
Fridge doesn't cool
well or runs all the time
Frost
forms rapidly or the unit does not defrost at all
Fridge
makes an unusual noise
Fridge
smells unusual
Water is leaking
underneath or inside the unit
Giving conscientious routine care, a fridge will usually perform its tasks for years with a minimum of problems. Fridges are categorized according to the way frost is removed from them.
Standard Fridge- Defrosts when the power is turned off and the frost is permitted to melt slowly away on it's own or with the aid of pans of hot water placed in the freezer.
- A heater that is turned on when the temperature on the evaporator reaches a preset point, keeps the fridge compartment free of frost, but the freezer requires manual defrosting every few months.
- Frost from both compartments is continually melted away by a heater that turns on for 20 -30 minutes, two or three times a day. Clearly, this type of fridge offers the ultimate in convenience, though it's somewhat more prone to problems and is considered less energy-efficient.
In automatically defrosted models, water from the melting frost flows out a drain in the floor of the fridge and into a pan, where it evaporates. Food particles can be carried along, clogging the drain and causing odors. Clean the drain regularly by following these steps:
Remove the stopper.
Use a pipe cleaner or similar device to push any accumulations through to the drain pan below.
Force a solution made from soap, ammonia, and water through the drain.
Empty the pan and wash it.
The door gasket, if washed often with soapy water, will usually last as long as the Fridge. Check to see if it is sealing well by closing a dollar bill in the door. If you feel a resistance when you pull it out, the gasket is holding. Repeat the test in several places. If your gasket does not pass this test, it should be replaced.
Temperature settings for fridge and freezer compartments are given arbitrary numbers. For example, number 1 usually indicates warmest, and number 9 indicates coldest, by most manufacturers. Generally, 37 degrees F is ideal for the fridge compartment, and 0 degrees F for the freezer. If you suspect a problem test the temperatures of each compartment with a fridge, or outdoor, thermometer.
Check for:
No power at the outlet.
Damaged power cord.
Remedies:
Check the fuse box/circuit breaker.
Check the outlet with a VOM or lamp.
If Fridge blows fuses, put it on its own circuit.
Replace the cord.
Check for:
Dirty condenser coils.
Defective condenser fan. (frost-free types)
Incorrect voltage reaching the unit.
Defective thermostat.
Defective compressor.
Remedies:
Clean the coils.
Check the fan.
Check the voltage with a VOM, then call the power company (if you supply your own power, then check it)if it's not between 105 and 125 volts.
Test the thermostat and replace if necessary.
Check for:
Wrong voltage reaching the unit.
Defective compressor.
Leaking refrigerant.
Dirty condenser coils.
Remedies:
Run the unit on its own circuit and check the voltage at the outlet.
Call a qualified tech.
Call a qualified tech.
Clean the coils.
Check for:
Thermostat on wrong setting.
Dirty condenser coils.
Damaged door gasket.
Sagging door.
Heavy frost accumulation.
Door is open too much.
Hot and humid weather.
Inside light on.
Wet insulation in the door and sides
Room too warm.
Damaged evaporator fan.
Damaged condenser fan
Defective defrost timer.
The refrigerant has leaked out.
Remedies:
Change the thermostat temperature.
Clean the coils.
Check the gaskets.
Straighten the door.
Defrost the unit more often.
Open the door as little as possible.
If the unit runs continuously, but cools well, there is no problem.
Check the door switch.
Open the unit on a dry day and let it dry out. Also, repair or replace cracked door jambs and panels.
Move the fridge to a cooler place or start cooling the room.
Check the fan for damage.
Check the fan for damage.
Check the timer for defects.
Call a qualified tech.
Check for:
Door open too much.
Sagging door.
Damaged door gasket
Uncovered food.
Clogged drains.
Damaged defrost timer, heater, or thermostat.
Remedies:
Open the door as little as possible.
Straighten the door.
Test the gasket and replace it.
Cover or seal all foods, especially liquids.
Open and clean all drains.
Check the timer, heater and thermostat for defects.
Check for:
Unit is not sitting level.
Rattling drain pan.
Hard or broken compressor mounts
Blocked fan blades.
Remedies:
Adjust the position of the unit.
Move the pan so it doesn't touch sides of the unit.
Replace the mounts.
Check the evaporator and compressor fans for obstructions.
Check for:
Clogged drains.
Dirty drain pan.
Remedies:
Open the drains and flush them.
Clean the pan and disinfect it.
Check for:
Broken drain hose or drain pan.
Clogged drains or full pan.
Remedies:
Replace the broken parts.
Open the drains or empty the drain pan.
